Safety Wire
Housekeeping
Refuel
WUC
General
100
This is the alternative to safety wire
What is safety cable (1-1A-8 / Chapter 16 / 16.1.2)
100
Supervisors may use this to identify the need for PPE
What is Job Safety Analysis Guide (AFI 91-203 PARA 1.6 / 4.11)
100
Fire bottles must be this far away from the fuel vent box while refueling
What is 25 feet (A-2-12JG-28 PAGE 84)
100
This is the T.O for WUC
What is 1C-17A-06
100
When the wind is above this many knots, you must install ground safety locks before bleeding gust dampers
What is 14 knots (1C-17A-2-10JG PARA 1-9)
200
This shall not be lock-wired to any part of fuel, oil, hydraulic, or oxygen system
What is an electrical connector (1-1A-8 / Chapter 16 / 16.1)
200
this is not allowed around moving parts of machinery
What is finger rings, jewelry (which includes watches) or loose clothing (AFI 91-203 PARA 4.11.6)
200
These are the two steps you must do when the VENT BOX OVERFILL light on GRC panel illuminates
What is Set POWER switch to the DEFUEL position. Set TANK 1 and TANK 4 BOOST PUMP switches to ON (A-2-12JG-28 PAGE 126)
200
This is the WUC for opening Cowling doors
What is the 01008 (1C-17A-06)
200
These are the three locations you can find the aircraft applicability codes
What are the 00GV, Plaque, inspection work cards (1C-17A-00GV Table 2-2)
300
This is the amount of turns required for .032 gauge wire require per inch
What is 7-12 turns (1-1A-8 / Chapter 16 / 16.1.4)
300
This is required to protect against small particles of falling debris whenever a task is above eye level and the worker must look up into the area being worked on.
What is eye protection (AFI 91-203 PARA 14.4.2)
300
Aircraft jacking, towing, and taxiing is not allowed with a lateral fuel imbalance between wings that exceeds how many lbs
What is 8000 lbs (A-2-12JG-28 PAGE 18)
300
This is the WUC for installing safety / support equipment
What is the 01018 (1C-17A-06)
300
The APU burns approximately this many pounds of fuel per hour
What is 500lbs per hour (1C-17A-2-49JG)
400
This is what you do when safety wire extends over 3 inches past the jaw of the pliers.
What is loosely wrap wire around pliers (1-1A-8 / Chapter 16 / 16.1.4)
400
This is the AFI for housekeeping / Air Force Consolidated Occupational Safety Instruction
What is the 91-203
400
This is the allowable vent fill box wing pressures while refueling
What is 1.3 - 1.7 psig (A-2-12JG-28 PAGE 116)
400
This is the WUC for special inspections
What is the 04199 (1C-17A-06)
400
You have this many brake applications with the brake accumulators
What is 10 brake applications (1C-17A-2-00GV PARA 12-33)
500
This T.O contains all the information on Safety Wire and Structural Hardware.
What is the 1-1A-8
500
These human factors can contribute to an unsafe attitude and negatively impact on worker performance
What are unhealthy emotions, job or domestic pressures, distractions, job knowledge, shift-work, hurrying or feeling rushed (AFI 91-203 PARA 2.1.1)
500
This type of radios are allowed near the refuel panel while refueling
What is intrinsically safe radios (A-2-12JG-28 PAGE 14)
500
This is the WUC for engine runs
What is the 01041 (1C-17A-06)
500
You can have all 4 aux pumps on with APU power for this amount of time
What is 5 minutes (1C-17A-2-49JG TASK 01-2)
M
e
n
u