Emergency Response
Natural disasters that are likely to occur in Connecticut.
Name at least 3
Fire or Explosion, Bomb Threat, Flood, Loss of Utilities, Weather (hurricane, tornado, snow)
Number of evacuation and assembly areas and location?
North east corner of the parking lot
3
This program is to ensure all chemicals would be evaluated and information about the hazards would be communicated to employees.
Hazard Communication Program
When should cell phones be used in production
Never
S.I.P Stand for?
Shelter In Place
The uncontrolled release of a hazardous chemical, either as a solid, liquid, or gas.
OR
Any accidental release of synthetic chemicals that pose a risk to the environment.
Chemical Spill
Provided to protect against hazards.
PPE
How long should you flush your eyes in an emergency eyewash station
15 seconds
Employee responsibilities to limit the risk of fires.
Name at least 3.
What is:
-Do not block doors
-Keep emergency equipment unblocked
-Keep work areas clean
-Inspect your work area
-Never daisy-chain cords (i.e., plugging a surge protector into a surge protector)
-Turn off non-essential equipment?
Name 3 Spill or Release Potentials
Oil, kolene salt, nitric acid,rise/washwaters, metal powders,Kerosene
Provide detailed health and safety information and precautions for handling hazardous substances, including:
-Product identity
-Manufacturer
-Hazardous ingredients
-Emergency and first aid procedures
-Physical/chemical properties
-Health hazards
-PPE
-Handling and storage
What is the function of the Safety Data Sheets?
Parking lot speed limit
5MPH
When should you report an incident?
Always!
Required distance to the nearest eyewash station
10 seconds or 55ft
When transferring a chemical from its original container to another container, what is required?
Secondary Label
What ratio is used for setting up an extension ladder at a safe angle
4:1
Evacuation of the plant may be initiated in one of three ways - name two ways
1. Fire Alarm Horn, activated by pulling fire alarm box
2. Public address announcement using the plant paging system
3. Portable air horn located near the rear shed
acronyms to remember during a fire emergency.
PASS: Point, Aim, Squeeze, & Sweep?
This common hazardous material can be found in older buildings. It was widely used in flooring and ceiling tiles and insulation piping. It must not be handled unless properly trained and equipped.
Asbestos
PPE is always the _____ resort when protecting workers.
Last