HAZ-COM
PPE
RCRA
EAP
MISC
100
What are the (4) routes of entry of a chemical into the human body?
1) Inhalation 2) Absorption 3) Ingestion 4) Injection
100
What does the Acronym ANSI Stand for?
American National Standards Institute
100
What does the Acronym RCRA stand for?
Resource Conservation and Recovery Act
100
Name two of the three locations where the Contigency Plan is located at LPI-Billings.
1) Front office Hallway 2) Cabinet located outside the production supervisor office. 3) Knox box on attached to the front (main) gate.
100
If a spill presents a threat to the public or waters of the state or is a SARA and/or CERCLA reportable, the company must contact what three agencies?
1) STATE (MTDEQ) 2) LEPC (Local emergency Planning Committee) 3) National Response Center
200
What are the (4) "Hierarchy of Controls"?
1) Engineering Controls 2) Safet Work Practices and Procedures 3) Administrative Controls 4) Personal Protective Equipment
200
The GME-P100 respirator cartridge is the most commonly used cartridge used LPI Billings. What does the "Magenta" color on the cartridge indicate?
HEPA filter. >99.97% efficiency for reducing particulates.
200
When does the 90 day accumulation start date begin for a satellite location?
When the drum, or container is full?
200
What does the PASS acronym stand for with respect to portable fire extinguishers?
P- pull the pin A- Aim at the base of the fire S- Squeeze the handle S- Sweep back and forth at the base of the fire
200
When your respirator is not being used how should it be stored?
In a "clean" area sealed in a plastic bag to prevent contamination.
300
10% of LEL
What is the limit for working in an area with combustibles?
300
The yellow chem-splash coveralls used at LPI-Billings meet what level of protection? (Level A, Level B, Level C, or Level D)
Level C
300
Used waste oil, batteries, and light bulbs with mercury are what type of wastes under RCRA regulations?
Universal Wastes
300
How do you kill the power to the entire facility?
Turn off the four main breakers located on the South wall in the Circuit room #1.
300
What is the Assigned Protection Factor for Full-Face Air Purifying Respirator?
50
400
Each year as part of the PPE regulation, all companies are required to what type of assessment must be completed?
Hazard Assessment
400
Firms that store, treat or dispose more than 220lbs of hazardous waste per month fall into what category under RCRA?
Large Quantity Generator
400
Where is the valve to turn off the natural gas to the plant located?
Directly outside the South Door leading into WHSE #2.
400
A certain chemical has a TLV for an 8hr TWA of 11ppm. What is the maximum use concentration if an employee used a full faced air purifying respirator?
APF x TLV 50 x 11 ppm = 550ppm
500
According to the DUPONT MSDS, what is the Vapor Density of 60% DMA used at our facility?
1.6 (Page 7)
500
In addition to annual fit tests, what two tests are required after each time the respirator is put on?
1) Positive Pressure Test- Placing palm over exhalation valve and slightly breath out - Respirator shall push away from face. 2) Negative Pressure Test - Palms are place over the respirator cartridge and slightly breath in - Respirator shall pull towards the face and create a vacuum.
500
What (4) chemical characteristics are considered by RCRA and DOT as hazardous materials or hazardous waste?
1) Ignightability 2) Reactivity 3) Corrosivity 4) Toxicity
500
What is the primary cause of workplace deaths in the workplace?
Acts of violence
500
What is the term used for accumulation of materials that are potentially recyclable; however, there is no feasible recycling market?
Speculative Accumulation
M
e
n
u