Electrical
Maximum voltage technicians can work on without requiring PPE
50 Volts AC
Minimum radius of combustibles in a hot work area is
35 feet
List the PPE required to enter the dock yards.
Working radio, high visibility vest, and flashlight in times of darkness. (and a spotter)
How many days a week does a tech need to fill out a pre-use inspection for a wave?
Every day the tech uses it!
PPE stands for...
Personal Protective Equipment
Sticker placed on an electrical panel which indicates how severe the electrical threat is (hint: gives you important information for PPE requirements)
Arc Flash Label
True or False:
In the event of a building fire, the fire extinguishers are in place for RME to use to put out fires on critical equipment.
False, fire extinguishers are in place to be used for clearing paths to emergency exits.
Yellow 5s tape is for...
Trash (and dock plates)
PIT operators must be re-certified every ___ years
3
MTHA means...
Maintenance Task Hazard Analysis
Maximum voltage blue badge technicians may be exposed to, even with PPE
480 Volts AC, anything higher is contracted out.
Painful muscle spasms following hard physical work; can occur during work or rest.
Heat cramps
Minimum green mile width is...
36" minimum
True or false: Working on a ladder can be considered elevated work.
True, if it is over 4 feet high
NFPA means...
National Fire Protection Agency
Electrical cords shall not be used as a replacement for permanent wiring. Temporary use shall not exceed...
90 days (if no one got it right, give it to who got closest)
How long must a fire watch period last after hot work?
4 hours
Orange/Black striped 5S tape is for...
AGVs
PIT max speed should be set at
5 mph
OSHA stands for...
Occupational Safety and Health Administration
If you have 110 vac power source, and a piece of equipment drawing 3 amps, then how many watts are being used?
330 watts
True or False: All RME employees need to have CPR training completed. If so, how long does the certification last for?
Yes, every 2 years.
5S stands for:...... (lol... good luck).......
Sort, Straighten, Shine, Standardize, and Sustain
You didn't know that?? If anyone got that right, give them extra Tech Safety Bucks!
Minimum width of a PIT lane is...
8' wide for single, and 14.5' for two way PIT lanes
The department responsible for ensuring that Amazon meets federal, state, and company requirements for workplace and process controls relating to environment, health, and safe practices.
EHS.....But Safety Is Everyone's Job!