Safety events 1
What is the procedures to reset a circuit breaker?
Can only operate it less or equal to 1.2 cal/cm^2. One time only.
When is it necessary to activate an alarm?
At any emergency or Potential emergency pull alarm. Call (256) or radio 23 (EHS) or Gatehouse 1 (266).
What safeguards are in place to prevent interactions between Pedestrians and mother vehicles (forklifts, trucks, buggies, and bikes)?
Blue lights, 8-foot red barrier light, horns, walking paths for pedestrians.
What is Ergonomics?
Implement work requirements to human capabilities.
Where is AN located on-site?
Dike 7, Pumphouse 9
Describe EVAC process and location route.
At gatehouse 1, Gate beside turnstile 2, Gate behind building 70.
What are the lifting limitations?
55 pounds or you will have to use two people or mechanical means.
when can you not use Respirators?
In an oxygen-deprived setting.
Make sure the pin and zip tie is intact, the valve says it's full or in the green, and no obstruction in front of it.
Monthly
Where do you dispose of aerosol cans?
North shop ( Maintenance)
What is the procedure for sheltering in place for chemical hazards?
Tape up all windows and doors shut down the HVAC system, listen for instructions on the radio.
Where are Vapor horns located, and what do you do if the alarm sounds?
F unit, D&E unit, polymers, raw materials.
Use Escape Respirator, leave Immediately.
RUN AWAY!!!!!!
What is RTO, and why is it important?
Return to operations.
To prevent LOPC's and hazards, in general, occurring before an initial release of the product.
What is BBP, and why is it important?
Behavioral Board Performace.
To ensure compliance with procedures and safety issues that may arise.
What is a MOC? Who is the initiator and the change owner?
Need to change a procedure or improve it. (Management of change)
Peron who finds the change is the initiator.
Person who writes the change is the owner.
What and where are the different kinds of trash bins?
General- west side/ spray dryer area.
Electronics- Behind building 28.
Cardboard- Polymer Drive.
Batteries - Elect shop
Contaminated rags - specialised waste drums.
What is NON-SSIS, and what are examples?
Equipment that must be manually operated.
Wheel valve, Fire extinguichers.
What is the purpose of LEV and VE
To keep harmful contaminates from a person's lungs.
How do you identify and respond to suspicious activity or behavior?
Someone asking questions, visually scanning area outside access, no Badge, out of the vehicle without an escort.
Report immediately to EHS or guardhouse by phone or radio.
How do use a fire extinguisher, and when not to use it?
P.A.S.S- pull aim squeeze. sweep
Not after the incipient stage.
What is a CSE, and where do you find the information on what spaces are considered CSE?
Any space with limited entry and exit points. Not somewhere that can have continuous work performed.
EDMS confined space list. It will tell you where confined spaces may be.
What is SSIS equipment, and what are some examples?
Equipment that responds when certain conditions are met.
Pressure relief valves, sprinkler systems.
What is the user password for the contingency computers and where are they found?
FGL12031, Happy 1234
Polymer Bulk Shack, Boiler House Control Room, Polymers Red Tag Room, Laboratory far west wall, Emulsions Conference Room, Maintenance upstairs, 1st door on left, back office, East End Label Shack, are places that Contingency computers can be found.
What is ERL, and what is their role?
What is IRL, and what is their role?
Emergency Response leader leads site during an emergency.
Immediate response leader just responds and leads department during emergency and liaison to ERL.
Stop-Process or change it.
Substitute with another material.
Ventilation, guarding.
Procedures, PTHA safety permits.