General Knowledge
"We'll work all the overtime we need, to prevent contractors from coming back here"
Who is Rodney Bunn?
The full name for the acronym PPE is...
What is Personal Protective Equipment?
If the Back Up Camera is inoperative, the Loader shall be immediallty_______ by the Operator.
What is LOTO?
A ______ & _______shall be posted on every container that contains a hazardous chemical.
What is A Label & Placard?
The device should be engaged if your engine fails during operation so you can safety steer the machine to a stop.
What is the Auxiliary Steering?
This safety device is to be used before putting a piece of equipment into motion.
What is a horn?
MSHA standard dictates "This PPE must be worn whenever there is a danger of falling".
What is a safety harness & lanyard
A safety item located on the left side of the loader to allow the operator to safely descend the loader if a fire erupts near the engine and restricts stair use.
What is Escape Ladder?
MSHA's Hazardous Communication Standard is also refered to as Part_______.
What is Part 47?
This switch shall be disconnected at the end of every shift to help prevent fire or theft.
What is Master Switch?
This Federal Regulatory Agency is mandated by Congress to perform 2 inspections per year at surface mines, and 4 inspections per year at underground mines.
Who is MSHA?
Prescription safety glasses are recognized as PPE but must be equipped with________.
What is Side Sheilds？
To maintain Loader Efficiency, a ______ minute load time goal is expected when conditions are optimal.
What is 2.1?
A "No Smoking or Open Flame" sign posted means that you must not smoke or have an open flame within ______ft of that sign.
What is 25?
When ascending or descending any piece of equipment, you should use ______________?
What is 3 Points of Contact?
If you see something.
What is say/do something?
General required PPE for the Longview site is ________, ________, _________, _________ & ________.
What is Hard Hat, Safety Glasses, Hi-Viz Clothing, Safety Toe Boots, & Gloves?
If the Loader Operator has any questions about their machine, all answers are located in the _________ and must be located in the machine.
What is Operators Manual?
___________ must be worn whenever hazardous chemicals are transfered.
What is Goggles?
If the ______________ alarm goes off and/or you smell smoke or see flames, you should; stop safely ASAP, turn key to off position if possible, use fire extinguisher if needed to exit the machine, and push _____________ plunger if safe to do so.
What is FSS (Fire Suppression System)?
All non-production vehicles must have one of these if traveling on a haulroad.
What is Beacon/Flashing Light?
Safety Harnesses & Lanyards expire ________ years from issue date.
What is 5?
A CAT certified parking/service brake test consists of; parking loader on safe level surface, engaging the parking brake(s), place loader in ______ gear, and slowly applying "high idle."
What is 3rd?
_____, ______, _____, & _____ must be displayed on a HAZ-Com Placard.
What is Health Hazard (blue), Fire Hazard (red), Instability (yellow), & Specific Hazard (white)?
A CAT Certified Brake Test on service/secondary/park brakes, consists of stopping truck on safe level surface, depress high gear limit buttons for raise/lower at the same time, move transmission to D, and slowly increase engine speed to ______ RPM. The machine should not move.
What is 1200?