Maintenance Tasks
Small gas engine manufacturers recommend servicing engines in this unit of measurement
What is Hours
Tell me the proper way to check oil on an engine with a dipstick
What is.... remove dipstick, wipe dry, reinsert, remove and check level
The first step of installing a spark plug is this
What is turning the plug by hand
Name me 3 types of air cleaners
What is Oil Wetted, Dry type and Dual Element
Coolant is a typical mix of....
50% Water and 50% antifreeze
Easiest task to keep an engine running longing and to prevent overheating is ....
What is Cleaning
There are 3 causes for the oil level to excessive drop in an engine...name one
What is, Oil leak or Worn seals or Hot running engine
What is the name of the tool to check the spark plug gap
What is feeler gauge
What is pores
When servicing an engine what is the acronym K.I.S.S. stand for
What is keep it simple stupid
What is
Proper carburetion
Correct ignition system operation
Adequate lubrication
Sufficient cooling
Proper compression
I said this is the number one most important step in replacing the oil filter... I even had a photo in the slide show what is it?
What is coat the o-ring with oil before installing
Dirty insulation or brittleness might be a sign of this...
What is worn spark plug wire
What is the proper way to clean an oil-wetted air cleaner?
What is remove from engine, wash with soapy water until water is clear, reoil filter and replace
This tool is used to check for RPM
What is tachometer
This type of booklet is legally required to be included with the purchase of any engine
What is an Owners Manual
When removing the flywheel using a puller, one of the arms must be located here
What is on the magnets
How much oil should be put into the combustion chamber before placing an engine in storage
What is 1 Tablespoon
Cleaning batteries terminals should be done in three steps, removing the cables (negative first), cleaning with these two materials, and then rinsing with clear water
What are baking soda and water
Lubricates for cables and linkages should be this material-based lube because it does not attract dirt
What is Silicone
This is the name of the white plastic inside of the crankcase breather assembly... (hint duck hunters also use these in the calls)
What is the reed valve
General manufacturer specs say spark plugs get torqued to what
What is 13-15 ft lbs
What is this tool
What is a Hydrometer
**FINAL**
Name the 4 spots a leak-down test can leak from.
What is
1) Intake Valve
2) Exhaust Valve
3) Head Gasket
4) Piston Rings