Quality and Records
What additional item is required for a 43.11 signoff that is not required for a 43.9 signoff
ACTT
What FAA Form is used to approve Major repairs and Alterations
FAA Form 337
The repair station certification holder shall conduct operations in accordance with what Code Of Federal Regulations?
14 CFR 145.
"I have looked in this panel 100 times and haven’t found a crack” Is an example of which of the “Dirty Dozen”
Complacency
What is max fuel system quantity in a standard configuration UH60A?
362 Gallons via gravity fueling
Are the Bell manuals approved or accepted data
Chapter 4 is Approved
All the rest are accepted
The purpose of this device is to protect an aircrafts electrical system from damage by interrupting the flow of electricity when there is an overcurrent or short circuit?
Circuit Breaker
What is the maximum pressure for pressure refueling?
300 GALS per minute at 55 PSI
- Joe Tells his MX team 608PJ must be RTS’d by tomorrow no matter what! Which of the dirty dozens could this put on the crew?
Pressure/Stress
What is the main rotor RPM of a UH60A?
258RPM
True or False We are required to complete a 337 for a major repair when performing a 34.5 beam repair
False
At what interval must an ATC Transponder system be certified?
Every 24 calendar months
What is the Emergency Procedure No. 1 HYD FLT CONTR caution light on and loss fluid is evident?
Land As Soon As Possible.
John asks “how ya’ll been signing off the 407-cargo mirror STC without the cable installed?” and Robert says.. "We just sign it". Which of the Dirty Dozen best describes this?
Norms
What hydraulic components have SAS actuators with retirement lives?
Yaw boost actuator, Roll SAS actuator, and Pitch/trim actuator
We do not perform FAR 43 Appendix D “Annuals”, what FAR allows us to (not) do that
14 CFR 91.409 (c)(4)
What is the first thing you should try if an aircraft radio is not working properly?
Turn the unit off, then back on
How must loads on the forward and aft cargo hooks be released if the DUAL HOOK fault light is on?
Manually
Who came up with and implemented the Dirty Dozen into the aviation industry?
Gordon Dupont
When was the first UH60 delivered to the Army for service?
1978
What formula does AC 43.13 provide to determine how much weight in ballast is required to move CG
Distance CG moves (X) A/C Weight
Ballast Weight= -------------------------------------------
Distance from ballast to new CG
What minimum size circuit breaker would be needed for a new 130 watt piece of equipment installed on a Bell 407?
5 amp breaker (Amps = Watts/Voltage)
What is the Emergency Procedure for the ENG XSMN HOT caution light ON?
EMER. ENG SHUTDOWN
FE: (AFFECTED ENG XMSN – CHECK)
LAND AS SOON AS POSSIBLE
What year was the “Dirty Dozen” introduced into the aviation industry?
1993
What is the max cargo floor weight limit capacity in pounds per square foot?
300