LOTO
Who are the LOTO Model Program Administrators?
Aaron Constable and Dave Paulmert
Pedestrians always have the right of way. T/F?
False. Pedestrians must stop and allow the mobile equipment to pass unless the operator stops and signals for the pedestrians to proceed.
What does IRS stand for?
Internal Responsibility System
What gets wetter the more it dries?
A towel
Who is the ugliest person in the electrical department?
Jeremy Downie
Emergency lock removal can be approved by the Department Head. T/F?
False. Emergency lock removal can only be approved by the plant manager and they must follow established procedures
Name 4 types of mobile equipment in the plant.
●Forklifts
●Pallet movers
●Front end loaders
●Dump trucks
●Snorkel lifts
●Scissor lifts
●RTV
●Tractors
●Note: Cushmans, gold carts, and mules do fall under the program requirement
What is our safety goal for 2021?
Zero restricted and lost time injuries
What can one catch that is not thrown?
A cold
What does MSDS stand for?
Material Safety Data Sheet
What are the LOTO 7 steps to safety?
●NOTIFY all affected employees of lockout and reason
●SHUTDOWN the equipment using normal stopping procedure
●ISOLATE energy sources
●LOCKOUT energy isolating devices with your assigned locks and tags
●TEST/JOG isolations and turn controls to off position
●CHECK to ensure that no one is exposed, and guards are installed. (after servicing the equipment)
RE-ENERGIZE the system after removing lockout.
Anyone who is deemed medically fit and has completed OTIS training can operate a fork truck. T/F?
False. They must also review and understand the model program, complete the equipment specific training, review the safety rules and owner’s manual for the equipment they are operating, demonstrate the ability to perform a pre-shift inspection, pass a performance test, demonstrate understanding of applicable safety rules and understand the reporting requirement for mobile equipment incidents.
For accident investigations, what is the minimum team required?
ANI reporter, JHSC member, department hourly operator, GF/Foreman/Supervisor 2/Dept. Manager.
If you have a bowl with six apples and you take away four, how many do you have?
The four you took
Name 2 employees that are on 40+ years CGC wall of fame.
Steve Mackenzie
Brian Mackenzie
William Hussey
Dwayne Pankhurst
Name 3 types of energy hazards.
Electricity
Fluid Pressure
Air Pressure
Kinetic Energy
Potential Energy
Pressurized Liquids and Gases
What is a Safety Zone and how can you identify it?
A Safety Zone is an area marked with an orange box w/ hash marks. Mobile equipment and pedestrians cannot both be in the safety zone at the same time.
If a JHSC member is not available for the accident investigation. Who can replace them?
If a JHSC member is not available another hourly employee will be substituted
What gets sharper the more you use it?
Your brain
Name 3 types of crisis situations.
Medical
Weather
Fire/Explosion
HAZMAT
Public Emergency
Power Failure
International Incident
An out of service lock MUST be accompanied by what?
What must be stated on the _____?
An Out of Service tag MUST accompany the OSL. The tag will state the employee’s NAME; DATE; TIME; and an explanation why the equipment is out of service
What should you do before dismounting a fork truck?
always straighten steering wheels, put vehicle in neutral, lower load to floor, set hand brake, switch off engine, and use reverse 3 point dismount
What are the 3 points of the Coaching Triangle ?
Questions
Affirmation
Critical Feedback
First you throw away my outside and cook the inside. Then you eat my outside and throw away my inside. What am I?
Corn on the cob. Because you throw away the husk, cook the corn. Then you eat the kernels, and throw away the cob.
What are 3 symptoms of heat exhaustion?
• Weakness
• Dizziness
• Nausea
• Headache
• Heavy sweating
• Clammy skin