Safety
Emergencies
Ergonomics
PPE
Surprise
100
EH&S stand for this
What is Environmental Health & Safety
100
The place where everyone meets during a fire emergency
What is the Employee Parking Lot?
100
True or false?
Tight fitting clothing negatively affects ergonomics.
What is True?
100
PPE stand for this
What is Personal Protective Equipment?
100
True or False?
If you come across a spill and you clean it up, you should you report it as a safety concern.
What is True? Report the spill to record the issue and note that it has been cleaned up so no action is needed. Repeated spills in a location may warrant preventative measures.
200
This is the name of the safety concern reporting software, and it is found in one of these locations.
What is (a) Gensuite and (b) either the Devens homepage link EHS concern report or the GTFSD "near miss reporting" link?
200
The nearest exit route from the Nichols Conference Room
What is the Door to Lobby and out the main entrance?
200
The maximum weight one person is allowed to lift
What is 35 lbs
200
True or false?
I can wear my regular prescription glasses on the shop floor as long as I have safety shields on.
What is False? The lens material needs to be made from a similar material as safety glasses.
200
Name two of the four main causes of mistakes
What are:
Rushing
fatigue
complacency
frustration
300
The recommended minimum number of concern reports per employee per year
What is Four (4)?
300
The person who takes the IN/OUT boards during an evacuation
Who is the First person exiting out that door, aka, Anyone?
300
One way (of several) to reduce eye fatigue when using a computer or smart phone
What is:
1. Turn on the "Night Light Mode" or use screen cover to filter out blue light
2. Every 20 minutes, look at something 20 feet away for 20 seconds.
3. Eliminate any glare on the screen
4. Blink Frequently to lubricate eyes
300
This person is responsible for enforcing PPE requirements
Who is your Immediate supervisor?
300
This hazard symbol means
What is An immediate skin, eye or respiratory tract irritant, or narcotic?
400
The primary method to dispose of chemicals
What is (1) to put in the Hazardous Waste Collection shelf or area or (2) a portable receptacle?
400
A laptop catches fire. This class of fire extinguisher is needed to put out the fire.
What is Class C?
400
The recommended angle between the forearm and the upper arm when typing to prevent strain and injury
What is 90 degrees?
400
Steel toe shoes need to be worn here on the shop floor
What is Anytime you cross the yellow lines on the floor?
400
The minimum required clearance for electrical cabinets (width and depth, in inches)
What is 30 inches wide by 36 inches deep?
500
The number one safety concern reported
What is Slips, Trips, and Falls?
500
In the event of a non-emergency type of injury, you or your supervisor need to call this number, and it can be easily found here.
What is Axiom which is found on posters located on bulletin boards throughout the facility?
500
The ideal lifting height range, called the strike zone, in inches
What is 39 to 48 inches from the floor?
(average for US men and women)
500
Name 6 different articles of PPE used in Devens
What are:
safety glasses
safety shoes
harnesses
ear plugs or earmuffs
hardhat
dust/face mask
gloves (heat, cryo, electrically insulated, disposable, cut-resistant - each type counts as one)
heat resistant arm protectors
500
This was the first recordable at Devens this year
300 Bonus Points: This was the near miss on the same machine a few months earlier
What is back of hand cut on lathe tool mounted on tool room lathe?
Bonus: What is the Chuck head fell off while lathe was turning?