S&E KPIs
What is MIR
Medical incident rate
When is a "K" turn to be used?
When you are facing forks first in the direction of travel when needing to go to the next aisle.
What inspection form needs completed before entering a trailer
Pre-trailer entry safety checklist
What is a GRC Audit or Loss Prevention Audit
Review risk for serious loss to property or life - common areas to review are fire and emergency response planning, controls and procedures
What does the ergonomic rule 40-80 indicate?
Lifting anything that weighs 40-80lbs requires a team lift.
How is MIR calculated
# of MIRs * 1M hours / facility hours worked
How long is a PIT certification valid
3 years
What are the 3 primary controls in dock safety
Dock lock, wheel chock, glad hand lock
What is the EHS Assessment
An internal assessment to measure overall compliance and CI in safety, environemntal and health. Sites performance on this drives SPS card performance in EHS
Define Ergonomics
What is waste recovery ratio
Amount of waste diverted from landfill
Define 3ft, 10ft rule
you must be 3ft from PIT in motion and 10ft if the forks are raised 5 or more feet off the ground
What is the over ride procedure for the docks?
When a dock lock cannot be used a supervisor or lead must perform an over ride and verify both wheels are chocked and glad hand lock used
What is a CAMS audit?
Compliance audit
Define "early intervention"
Early intervention is a proactive approach to treat minor to moderate MSD before progressing to injuries.
How is waste to energy CAP calculated?
Total plant waste recycled, reclaimed or reused divided by total plant waste
Where can you find the capacity of a forklift?
On the load plate
What is required when entering the yard as a pedestrian?
Buddy
14001 and 45001
ISO EMS and OH&SMS standards
Name the 5 hierarchy of controls
Eliminate
Substitution
Engineering
Administrative
PPE
What was the last safety action implemented in your department?
....
What must be done before charging a lift?
powering down of charger and lift before connecting or disconnecting charging cables
When is a jack stand required?
For trailers and containers <48ft long
Name 4 of our top hazards located on our risk register
PIT, Docks, Fall, Electrical
Name 2 SPS certified ergonomic specialists local to Mechanicsburg
Martha, Austin