hcp

Catofin Board

100

Which of the following conditions will trip the RAH burners? All that Apply:

a. Low-Low WHB Steam drum level

b. High high Rx Spent air temperature.

c. Low-Low vacuum pressure on hydrocarbon header

d. High high plenum temperature on RX 1-8

What is:

a. Low-Low WHB Steam drum level.

b. High high Rx Spent air temperature.

200

What is the minimum air flow required to the RAH from the Gts and Air Compressors to maintain is burner ignition?

            a. 1.0 MMLB/HR

            b. 1.5 MMLB/HR

            c. 2.0 MMLB/HR

            d. 2.5 MMLB/HR

What is:

b. 1.5 MMLB/HR

300

4005F Hydraulic oil tank low temperature shutdown is?

            a. 90°F

            b. 85°F

            c. 45° with 120 second’s delay.

            d. No trip associated with low temperature.

What is:

d. No trip associated with low temperature.

400

The reactors are down, your told to heatup the reactors up slowly manually, you instruct the outside technician to open which valves?

                a. Air outlet then air inlet, rest of the valves closed.         

                b. Air inlet then air outlet, rest of the valves closed.

                c. Hydrocarbon inlet then hydrocarbon outlet, rest of the valves closed.

                d. Hydrocarbon outlet then hydrocarbon inlet, rest of the valves closed.

What is:

b. Air inlet then air outlet, rest of the valves closed.

500

Gt 5 is a different model, than 1-4, what is the max discharge temperature  it will run?

                a. 1184°F

                b. 1200°F

                c. 1250°F

                d. 1290°F

What is: 

d. 1290°F

Distillation Board

100

If the Expander/Re-compressor trips, what should you do? All that Apply

A. Cut rates to PSA.

B. Lower ops factor.

C. Lower fuel gas pressure.

D. Open PSA bypass PIC3064.

What is: 

A. Cut rates to PSA.

B. Lower ops factor.

200

You get a call from the pipeline saying the concentration of ethane in the incoming pipeline propane feed is going to be high, what can we do? Multiple Choice.

A. Put in service Ethane feed protection on 106E.

B. Cool down MRC in preparation.

C. Maximize Cooling through 602CX.

D. Cut Plant Rates.

What is:

D. Cut Plant Rates.

300

PSA trips you lose all reject gas to fuel, TI3023 starts to heat up, what must you do?  Multiple Choice

A) Open PIC3013 to put more to fuel.

B) Slow up the 609JT expander.

C) Open PSA bypass PIC3064.

D) Cut Feed to PSA FIC3065.

What is: 

C) Open PSA bypass PIC3064.

400

Avon trips, steam shedding goes in to affect, what do you expect to see on C3 splitter? All that Apply.

a. Propane concentration increasing in the overhead.

b. Increase in pressure on 701E.

c. 727F level going lower.

d. Propylene concentration increasing in the bottoms of 701E.

e. Bottom level increase

What is

b. Increase in pressure on 701E.

c. 727F level going lower.

d. Propylene concentration increasing in the bottoms of 701E.

e. Bottom level increase

500

Why is PDIC3067 so important to 701E operations? Multiple Choice

A. Let’s you know that 116J first stage has plenty of room to move forward.

B. Let’s you know the difference in pressure between 116J first stage and 708F, to prevent back flow.

C. The higher the DP, is an indication that you can open the reboiler valves more.

D. Is an indication that 708F pressure is higher than 701E, so reflux will flow to the column.

What Is: 

B. Let’s you know the difference in pressure between 116J first stage and 708F, to prevent back flow.

Utilities

100

2200-F receives feed from:

A. M-1002

B. 2101-F

C. 300-F

D. 2211-F

What is

b. 2101-F

200

The storm water tanks receive water from the _____and_____Basins.

A. Turning

B. Bottom

C. Guard

D. Diversion

What Is 

C. Guard

D. Diversion

300

What is the maximum flow rate in GPM for each Lamella?

a. 900

b. 800

c. 1000

d. 1200

What is 

c. 1000

400

If CIWA pressure is lost and cannot be restored in a timely manner, what must be done?

A. Line up fire water to the cooling water header

B. Shutdown raw water treating chemicals

C. Line up well water to the Clearwell

D. Shutdown the unit

What is 

b. Shutdown raw water treating chemicals

c. Line up well water to the Clearwater

500

Which chemical at raw water is used to bridge suspended solids creating a dense floc which settles out the mud rapidly?

A. Sodium Bisulfite

B. 892E

C. Sodium Hypochlorite

D. 817L

What is

D. 817L

Bonus (Outside Ops)

100

There are ___ burners separated into __ groups in the 4002B Waste Heat Boiler Duct Burner.

a. 14/3

b. 14/4

c. 10/3

d. 14/7

What is

a. 14/3

200

The gases from the vapor space of M-1003 are sent where?

a. Fume header

b. Flare header

c. Atmosphere

d. Carbon canisters

What is 

c. Atmosphere

300

What is the purpose of the Bray Valves.

a. Provides a positive close if DP slips below 1.5psi

b. Is the new control valve for air flow from Atlas Copcos.

c. Acts as a check valve and prevents back flow.

d. New jumper line between Atlas Copcos and Avons.

What is

a. Provides a positive close if DP slips below 1.5psi

c. Acts as a check valve and prevents back flow.

400

Where does the potable water enter the plant?

a. East of GT 5

b. At the potable water tanks

c. South of M-1008

d. At Guard Shack main gate

What is

a. East of GT 5

500

The hot gas used to regenerate the COS beds is _________.

a. Refined propylene

b. Natural Gas

c. Propane

d. Hydrogen

What is

b. Natural Gas

Random ;)

100

This sport's popularity has skyrocketed 158.6% in the last 3 years.

What is pickleball! (For reals lets go play!)

200

When did Mexico obtain its independence? Margaritas?

What is September 16

300

α = (y_a / x_a) / (y_b /x_b)

What is relative volatility 

400

Which animal is the mascot for Hufflepuff house in the Harry Potter books?

What is a badger

500

Everyone knows the name James T. Kirk. What's that "T" stand for?

What is Tiberius