Show:
Fibre rope
wire rope and chain
material handling
moving loads
knots and crane signals
100

This rope is light yellow in color, and is available in 6 grades

What is manila rope . 

100
the wires and strands of this rope are wound in the same direction
What is lang lay rope
100
when a load is suspended, where is its centre of gravity
What is directly below the hook
100
where must capacity of jib or overhead cranes be?
What is displayed on the device
100

which knot forms a non slip loop?

What is bowline

200
Which rope is 87% as strong as nylon
What is polyester rope
200
the minimum chain grade acceptable for overhead lifting
What is Gr 8
200
calculate the WLL for workers, when using 1" wire rope with a breaking strength of 7000kg
What is 700 kg
200
what is the sound or light signal for lower
What is three bells or flashes
200
the knot that multiplies the tension you apply
What is single dutchman
300
how much will nylon rope stretch when loaded to its breaking point
What is 40% of its original length
300
explain 6x19 ordinary rope
What is wire rope composed of 6 strands, with 19 wires within each strand
300
hooks must be permanently removed from service if their throat openings have increased by....
What is 15%
300
where should all turns be made on motorized forklifts
What is on level surfaces
300
demonstrate that you would like to use the whip line
What is hand to elbow or index finger to shoulder
400
Which type of rope has the best insulating properties
What is polypropylene
400
what four standard patterns are used within a strand?
What is ordinary, seale, warrington & filler
400

calculate the WLL of a three part bridle. one slings WLL=1000 kg H=3.5m L=4m

Found on page 61

What is 1750 kg

400
how do manual forklifts raise their loads
What is pumping a handle
400
demonstrate booming up and holding the load
What is hand pumping with thumb up
500

the maximum load imposed on a rope for lifting personnel should never be more than this

What is 1/10th of its breaking strength or a design factor of 10

500

When installing cable clips, the U-bolt part of the clip must bear on which part of the rope

DAILY DOUBLE

What is dead end of the rope

Never saddle a dead horse

500

DAILY DOUBLE!!!

When rigging a loose bundle of round stock, what sling arrangement would be used? AND what degree of sling angle must you watch for?

What is double-wrapped basket hitch and watch for less than 60° sling angle

500

what must not be carried on the forks of a forklift? 

What is  personnel 

500

Demonstrate hoist up slowly and then dog the load.

What is hand over moving finger then clasp hands in front of you