PED
Severe Weather (HSEL0624)
Stop Work
Hazard Recognition
Safe Work Permits
Pot Luck
100
PED's
What is Personal Electronic Device's?
100
According to the Severe Weather Response Plan, the Employees responsibility in the event of approaching severe weather.
What is report to work as scheduled unless weather conditions make it impractical and stay in touch with Supervisor for scheduling changes.
100
When a person identifies a perceived unsafe condition, act, error, omission, or lack of understanding that could result in an undesirable event, they must immediately initiate _____________.
What is a stop work intervention with the person(s) potentially at risk.
100
Troubleshooting equipment or process lines when there is any potential of a splash hazard or unexpected flying debris requires at a minimum this PPE.
What are goggles and face shields (or Full Face Respirator)?
Take time to review potential hazards (just like what is done during the issuance of a permit) before troubleshooting any equipment/lines.
100
Is large enough & so configured that an employee can bodily enter & perform work; has limited means for entry or exit. Is not designed for continuous employee occupancy.
What is a Confined Space?
(ie: tanks, vessels, storage bins, hoppers, vaults & pits, trenches)
100
NAME THE TASK.
What is moving a colony of honey bees from the HTU.
On 5/16 about 1pm during the shutdown a swarm of honey bees appeared on the process. (Normally less than 24 hours they will leave. However, the 'scout bees' had determined the column would make for a good hive location and moved the colony in).
On 5/17 about 2:00pm a honey bee Extractor (along with his assistant) smoked all the bees out and captured the Queen bee to encourage all the other bees into a transport box. By 9:00pm when the Bee guy came back to pickup the box, all but a few bees were outside the box (99% of the colony was in the box).
200
PED (HSEL0451) does not apply to what type of equipment?
What is “intrinsically safe” equipment?
(also, work related diagnostic equipment that is used by technicians)
200
Conditions are favorable for the development of severe weather.
What is a weather Watch?
200
Stop work events should be documented here.
What is a blue card?
200
What is FALSE? The blue dumpsters are for only oily waste or materials that are contaminated with oil.
The Red trash bins are for office trash and clean cardboard waste.
200
Meeting that is conducted prior to a Confined Space entry.
What is a CS Pre-Entry meeting?
To cover expectations for safe execution, roles & responsibilities of entrants, attendant & entry supervisor, rescue plan covered
200
Name and Title.
Who is Rodney Webb, Shipping/Receiving Manager (and Tour Guide Extraordinaire)?
300
The use of cameras(incl. phone cameras) to take pictures or video is restricted in ALL areas of the Re-Refinery without an approved ___________.
What is a Camera Pass issued by the HSSE Dept (a hot work permit may also be required).
300
An alert issued by national weather forecasting agencies to the public that severe thunderstorms with tornadoes are imminent or occurring is a tornado warning. The locations for employees to take shelter are
What is Ops Control Room and Men's Room in the Main Building?
300
A good practice to get an employees attention to stop work and review their work area is to use this.
What is the Commitment Coin?
300
At least one task this PPE is used for at the Re-Refinery:
What is line breaking caustic line, confined space entry, dumping and cleaning up hydrated lime?
(all reasonable answers will be accepted - until the PPE Matrix is completed).
300
Structure that must be inspected & signed off by a competent person prior to being used.
What is a scaffold?
300
According to the Re-Refinery Bonus Program (ADML0621), other than completing a Blue Card, name the way you can earn credit toward employee participation.
What are Audits (Auditor and/or Auditee)?
400
Personal phones (intrinsically safe) in 'off' or silent mode can be carried in the Warehouse areas (Upper/Lower).
True or False
What is False.
400
At least three methods to detect lightning in the area?
1. Thorguard L75
2. Weather Bug App (or Spark App)
3. Eyes/Ears of employee/contractor
400
Contractors have the same responsibility and authority as company employees to stop work when an imminent hazard to persons, property or the environment is identified. Contractors are trained and made aware of the Stop Work policy during ___________________.
What is Safety Orientation (or during the issuing of the Safe Work Permit).
--Thus another example of the importance of the Safety Orientation for all Contractors.
400
The yellow painted area.
What is the Safe Walking Path?
400
Name 3 of the 7 life critical safety tasks.
What are:
1. Hot Work
2. LOTO (Energy Control)
3. Line Breaking
4. Confined Spaces
5. Fall Protection (Elevated Work)
6. Live Electrical
7. Excavation
400
The warning is noted in the Severe Weather Procedure:
"...All work from fixed elevated platforms must cease immediately. Also, outside Elevated work permits are now cancelled. Outside activities should be limited until further notice."
What is the High Wind Warning?
MEWP: Work from mobile elevated work platforms (MEWP) must cease with sustained winds over 20mph and/or gusts over 27mph. Activities may resume when sustained winds are below 20mph and there has been no wind gusts greater than 25mph for 30 minutes
CRANES: All crane lift activity must cease with sustained winds or gusts over 22mph and must not resume until sustained winds are below 22mph for 30 minutes. The certified crane operator has the authority not to perform the lift in windy conditions if he/she feels it is not safe. Some crane activity has different wind thresholds and the most stringent rule must be followed.
FIXED PLATFORMS/SCAFFOLD: Work from fixed elevated platforms are prohibited during high wind warnings (sustained winds of 40 mph or higher for one hour or more or wind gusts of 58 mph or higher for one hour or more). Any time a critical task is required on a fixed elevated platform during a high wind warning, 100% tie-off is required. Access to fixed platforms may proceed once high wind warning conditions have past (greater than one hour
500
Class ____, Division _______ devices are required to be utilized in areas that are designated hot work areas.
What is Class 1, Division 1 (or 2) devices.
500
The announcement "...All confined space entry permits are now cancelled and outside activities should be limited until further notice." is repeated how often when in a Hight Heat Advisory.
What is the every 3 hours until the plant is out of the High Heat Advisory?
500
According to the Stop Work Authority policy- all Stop works are reviewed by ____________________.
Who is the Safety Committee at the next committee meeting and included in the meeting minutes?
500
Name at least two health hazards of Hydrated Lime.
What is a skin irritation or burning, serious eye damage including blindness, respiratory irritation, lung damage from prolonged exposure, cancer through inhalation?
PPE Includes: Full Face Respirator, gloves, tyvek suit and PVC boots (keep from tracking throughout the plant)
500
DAILY DOUBLE!!!
Q1. Missing?
Q2. Name another hazard
A1. What is the barricade tag?
A2. What is the hose in the walk path? (or the shin knock in the background w/o an orange cone)
500
DAILY DOUBLE!!!!
Q1: In the Red Circle.
Q2: Purpose.
A1. What is a trench box?
A2. It is used to protect employees working in the trench >5' (Trenches >4' are considered confined spaces).
600
PEDs can only be used in _________________ __________________ _________________ areas while on your break.
(Names Three Areas)
1. break/ lunch areas as defined by the departmental manager
2. smoke shack
3. locker rooms
4. bathrooms
5. picnic area
6. employee parking lot
600
Work from MEWP (Mobile Elevated Work Platforms) must ceases is sustained winds are over ______ mph and/or gusts over _____ mph
What is 20mph and gusts over 27mph?
Activity resumes when winds are below 20mph and no gusts greater than 25mph for 30minutes
600
Stop Work involves a stop, notify, correct, and _____________ approach for the resolution.
What is Resume?
600
Name two hazards:
What is the housekeeping of the shrink wrap and the loss of containment of the lime (health hazard).
Also, will accept the leaning bags stacked in the background.
600
DAILY DOUBLE!!!
Q1: In the Red Circle.
Q2: Purpose.
A1. Carbon Canisters Filters
A2. Used for loading HTLF - control odors in the neighborhood.