Office Safety
Where is the nearest fire extinguisher?
The other side of the wall outside Don's Office
What is Ergonomics?
The study of people's efficiency in their working environment
Where is this locations muster point?
Employee parking lot
What does the acronym OSHA stand for?
Occupational Safety and Health Administration
How many divisions of Chief are there? What are they?
(7) Ag, construction, structural steel, transportation, factory built housing (Bona Villa), Fabrication, Ethanol
Name 2 categories of office safety hazards?
Slips, Trips, Falls
Ergonomics
Natural Disasters
Electrical
What does the acronym MSD stand for?
MusculoSkeletal Disorder
What does the word "egress" mean?
the action of going out of or leaving a place
Exit
Fill in the blank:
(a) Each employer --
(1) shall furnish to each of his employees employment and a place of employment which are free from recognized ______ that are causing or are likely to cause death or serious physical harm to his/her employees;
Hazards
Where is the oldest constant running Ethanol plant in the nation located?
Hastings (Chief Ethanol)
What is the proper lifting technique if you are lifting by hand?
Lift with legs and not your back
Do not twist
What are two symptoms of an MSD?
Pain Swelling Tightness Stiffness
Discomfort Soreness Burning Tingling
Coldness Numbness
What are the proper steps to follow when using a fire extinguisher?
Pull the pin
Aim at the base of the fire
Squeeze the handle
Sweep side to side
What year was the OSHA Act passed?
1970
What is the name of the Ethanol division General Manager?
Wayne Garrett
How can you prevent slip, trips, and fall in/around your office?
Housekeeping
Paying attention
Keeping a clear path
Scoop/Salt the walks
What is one of the risk factors for developing a MSD?
Repetition
Awkward Posture
Contact Stress
Force
Vibration
What document is used to share information about a chemical?
Safety Data Sheet
For the past 11 years, what OSHA regulation has been the most cited violation?
Fall Protection
According to current industry standards, one bushel of corn produces approximately ____ gallons of ethanol.
2.8
What does OSHA regulation 1910.22(a)(1) say?
All places of employment, passageways, storerooms, service rooms, and walking-working surfaces are kept in a clean, orderly, and sanitary condition.
What is contact stress in regards to MSDs?
Contact stress results from occasional, repeated or continuous contact between soft body tissue and a hard or sharp object, such as workstation edges, tools, machinery, products or the floor.
Fill in the word for this OSHA regulation:
1910.37(b)(3)
Each exit route door must be free of ______ or signs that obscure the visibility of the exit route door
decorations
OSHA has 2 divisions, can you name them?
Compliance
Consultation
What is the vision of Lexington's Chief Ethanol Plant?
to contribute to a cleaner future through sustainable ethanol production and community impact