Controls
I can shut-down a reclaim water or solvent charge if I go low or high, respectfully.
What is on-line density meter?
Purpose of nitrogen introduction into a vessel?
What is inerting a flammable atmosphere?
Term for starving a pump of fluid and subsequently producing and collapsing vapor bubbles that has damaging effects on impellers.
What is cavitation?
Lowers the surface tension between two liquids or between a liquid and a solid to promote a more homogenous mixture.
What is a surfactant?
Must be done prior to removing the SWEECO screen from the kan-ban area.
What is fill-out SWEECO request form?
I ensure that water and steam are adequately mixed to get a representative temperature in the jacket loop.
What is a PIC-heater?
Must be done prior to material handler removing empty raw material drums from the area.
What is empty, label with an operator's initials, strapped, and bungs tightened shut?
Maximum discharge pressure of a AODD pump.
What is matches air supply pressure - ~100psig depending on usage.
Two of the most important analytical results we use to have a stable and long-lasting dispersion.
What is pH and particle size?
Makes TR10600 different than the other two rubber tanks.
What is three agitators? [Name them for extra credit]
The eventual location of non-condensed reclaim water and toluene that is stripped away.
What is waste - V24.
I am the safer version of anti-freeze that is used in our chilled-water system.
What is propylene glycol?
Purpose of keeping the solvent-tree hand-valve closed throughout a batch?
What is to prevent cross-contamination?
The sign of an unstable dispersion?
What is coagulation? What is "set-up"?
Purpose of knock-back condenser?
What is to prevent escaping VOCs and meet environmental permit requirements?
Purpose of a tempered water loop.
What is to provide suitable heating and cooling while minimizing water usage?
What is 5C and 10C?
The loss of ability to read numerous temperature sensors throughout Trout or Eminate that all occured at the same time [type of failure]?
What is a I/O card failure?
Result of water emulsifying in non-polar solvents causes this phenomenon to occur.
What is haze?
I have a low-rated (15psig) relief pressure to prevent over pressurization because I'm not U-stamped.
What is TR2600 jacket?
5 interlocks preventing ability to charge toluene to TR12600.
What is high level switch active, nitrogen valve not open, manual header block valve closed, bottom valve open, and HI pressure alarm active?
What concentration of caustic (NaOH) can become irritating to human skin?
What is only 1%? [Higher than 20% is generally considered possible to cause severe chemical burns]
I tell you when you are no longer receiving reclaim water or reclaim toluene and can alert you early on of poor decanter operation.
What are the on-line density meters?
The terminology for material to bond with itself and the terminology for material to bond with another material.
What is cohesion and adhesion?
Purpose of a knock out pot?
What is to prevent liquid entering and being entrained in the vacuum pump?