Fibre rope
wire rope and chain
material handling
moving loads
knots and crane signals
100

This rope is light yellow in color, and is available in 6 grades

What is manila rope . 

100

the wires and strands of this wire rope are wound in the same direction

What is lang lay rope

100

when a load is properly suspended, where is its centre of gravity

What is directly below the hook

100
where must capacity of jib or overhead cranes be?
What is displayed on the device
100

which knot forms a non slip loop?

What is bowline

200
Which rope is 87% as strong as nylon
What is polyester rope
200
the minimum chain grade acceptable for overhead lifting
What is Gr 8
200

A plain carbon steel plate 1ftx1ftx1inch thick will weigh? Also known as a square foot.

40.8lbs

200
what is the sound or light signal for lower
What is three bells or flashes
200
the knot that multiplies the tension you apply
What is single dutchman
300
how much will nylon rope stretch when loaded to its breaking point
What is 40% of its original length
300
explain 6x19 ordinary rope
What is wire rope composed of 6 strands, with 19 wires within each strand
300

DAILY DOUBLE!!!

When rigging a loose bundle of round stock, what sling arrangement would be used? AND what degree of sling angle must you watch for?

What is double-wrapped basket hitch and watch for less than 60° to the horizontal sling angle to prevent legs from sliding towards each other.

300
where should all turns be made on motorized forklifts
What is on level surfaces
300
demonstrate that you would like to use the whip line
What is hand to elbow or index finger to shoulder
400
Which type of rope has the best insulating properties
What is polypropylene
400

When installing cable clips, the U-bolt part of the clip must bear on which part of the rope

DAILY DOUBLE if you can tell me the "old saying" used on job sites.

What is dead end of the rope

Never saddle a dead horse

400

When performing a lift using a basket hitch configuration, what is the working load limit (WLL)

200%

400

how do manual forklifts (pallet jacks) raise their loads

What is pumping a handle

400

Demonstrate the signal for raise the boom

With your arm extended, fingers closed, thumb up

500

the maximum load imposed on a rope for lifting personnel should never be more than this

What is 1/10th of its breaking strength or a design factor of 10

500

what four standard patterns are used within a strand?

Seale, Warrington, ordinary, filler

500

hooks must be taken out of service when they exceed this amount of throat opening from original

15%

500

When is it acceptable to use welded lugs for hoisting (2 things)

When the welded lugs are certified by a professional engineer and installed by a ticketed welder

500

Demonstrate hoist up slowly and then dog the load.

What is hand over moving finger then clasp hands in front of you

M
e
n
u